Ford Expedition Lemon Law Claims

Safety recall

Air Bags: Sensor: Side Impact / Air Bags: Side/Window

NHTSA 21V805000 · Reported 2021-10-15 · Manufacturer campaign 21C26

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to …”

Safety recall

Engine

NHTSA 22V346000 · Reported 2022-05-17 · Manufacturer campaign 22S36

The campaign addresses fire risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “An engine compartment fire may occur while driving or parked, even with the ignition in the "Off" position.”

Park an affected vehicle outside and away from structures as instructed by the manufacturer. Confirm current precautions and repair arrangements.

Safety recall

Visibility: Windshield Wiper/Washer: Linkages

NHTSA 22V250000 · Reported 2022-04-14 · Manufacturer campaign 22S26

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The windshield wiper arms may break, causing the windshield wipers to fail.”

Safety recall

Equipment: Other: Owners/Service/Other Manual

NHTSA 23V420000 · Reported 2023-06-09 · Manufacturer campaign 23C20

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."”

Safety recall

Equipment: Other: Labels

NHTSA 24V852000 · Reported 2024-11-08 · Manufacturer campaign 24C39

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."”

Safety recall

Back Over Prevention: Software

NHTSA 25V442000 · Reported 2025-06-27 · Manufacturer campaign 25S72

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.”

Safety recall

Visibility: Sun/Moon Roof Assembly

NHTSA 25V729000 · Reported 2025-10-24 · Manufacturer campaign 25SB7

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.”

Safety recall

Back Over Prevention: Sensing System: Camera

NHTSA 25V048000 · Reported 2025-01-31 · Manufacturer campaign 25S05

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The rearview camera may display a blank or distorted image.”

Safety recall

Power Train: Automatic Transmission

NHTSA 26V402000 · Reported 2026-06-24 · Manufacturer campaign 26S48

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.”

Safety recall

Visibility: Windshield Wiper/Washer: Linkages

NHTSA 26V204000 · Reported 2026-03-31 · Manufacturer campaign 26S24

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The windshield wiper arms may break, causing the wipers to fail.”

Safety recall

Seat Belts: Pretensioner

NHTSA 26V344000 · Reported 2026-05-27 · Manufacturer campaign 26S34

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.”

Safety recall

Structure: Interior Panels: Center Console

NHTSA 26V368000 · Reported 2026-06-09 · Manufacturer campaign 26S38

The campaign addresses injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The chrome plating on the center console may bubble and peel, resulting in sharp edges.”

Consumer allegations · 110 distinct reports

Transmission and driveline

Received: 2021-08-21 through 2026-09-10

The text includes references to shifting or acceleration (71), warnings or diagnostic codes (35), inspection or repair procedures (10). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve gear selection, speed, load, vibration, and the repair procedure performed.

Consumer allegations · 58 distinct reports

Engine and cooling

Received: 2021-11-24 through 2026-09-10

The text includes references to warnings or diagnostic codes (10), shifting or acceleration (10), starting or stalling (4). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve engine warnings, temperature, operating conditions, fluid levels, and repair findings.

Consumer allegations · 38 distinct reports

Equipment and other reported systems

Received: 2022-05-31 through 2026-07-28

The text includes references to shifting or acceleration (16), warnings or diagnostic codes (6), charging or battery concerns (4). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 28 distinct reports

Visibility, cameras, and driver assistance

Received: 2021-10-11 through 2026-07-04

The text includes references to warnings or diagnostic codes (4), inspection or repair procedures (3), shifting or acceleration (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 23 distinct reports

Electrical systems and software

Received: 2021-11-24 through 2026-09-10

The text includes references to charging or battery concerns (9), warnings or diagnostic codes (4), shifting or acceleration (4). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 14 distinct reports

Fuel and propulsion

Received: 2024-08-15 through 2026-08-09

The text includes references to shifting or acceleration (8), warnings or diagnostic codes (7), starting or stalling (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve fuel or charging conditions, power loss, warning messages, and confirmed diagnosis.

Consumer allegations · 11 distinct reports

Body and closures

Received: 2024-04-02 through 2026-07-13

The text includes references to inspection or repair procedures (3), warnings or diagnostic codes (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the affected panel or closure, water entry, noise, photographs, and repair attempts.

Consumer allegations · 7 distinct reports

Airbags, belts, and seating

Received: 2022-11-03 through 2026-06-22

The text includes references to shifting or acceleration (3), warnings or diagnostic codes (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Consumer allegations · 5 distinct reports

Brakes and stability control

Received: 2022-07-01 through 2026-07-08

The text includes references to shifting or acceleration (3), starting or stalling (1), noise or vibration (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 2 distinct reports

Steering

Received: 2022-05-20 through 2024-12-11

The text includes references to warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Consumer allegations · 2 distinct reports

Lighting and signals

Received: 2024-11-18 through 2025-09-02

The text includes references to warnings or diagnostic codes (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the lamp or signal involved, conditions of use, warning indicators, and repair results.

Consumer allegations · 1 distinct reports

Suspension, wheels, and tires

Received: 2025-09-18

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Service information · 39 distinct communications

Equipment and other reported systems

Communication dates: 2021-05-12 through 2026-08-22

The text includes references to software or module updates (14), warnings or diagnostic codes (4), charging or battery concerns (4). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 36 distinct communications

Electrical systems and software

Communication dates: 2021-02-23 through 2026-07-21

The text includes references to software or module updates (15), charging or battery concerns (10), warnings or diagnostic codes (9). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 29 distinct communications

Transmission and driveline

Communication dates: 2021-04-07 through 2026-04-02

The text includes references to warnings or diagnostic codes (17), shifting or acceleration (11), noise or vibration (7). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 11 distinct communications

Engine and cooling

Communication dates: 2021-08-25 through 2025-11-10

The text includes references to leaks or water entry (3), warnings or diagnostic codes (2), noise or vibration (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check engine warnings, temperature, operating conditions, fluid levels, and repair findings against the document’s VIN, trim, and equipment limits.

Service information · 8 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2021-04-28 through 2025-10-21

The text includes references to software or module updates (4), warnings or diagnostic codes (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 7 distinct communications

Airbags, belts, and seating

Communication dates: 2021-07-22 through 2023-12-05

The text includes references to noise or vibration (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 4 distinct communications

Brakes and stability control

Communication dates: 2021-08-25 through 2024-09-12

The text includes references to noise or vibration (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

Service information · 3 distinct communications

Body and closures

Communication dates: 2022-03-09 through 2025-10-01

The text includes references to noise or vibration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Lighting and signals

Communication dates: 2021-12-14 through 2023-05-09

The text includes references to warnings or diagnostic codes (2), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the lamp or signal involved, conditions of use, warning indicators, and repair results against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Suspension, wheels, and tires

Communication dates: 2022-04-28

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check speed, road conditions, tire condition, alignment measurements, and replaced parts against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Fuel and propulsion

Communication dates: 2023-01-24

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

Agency record · No closure date in index

NU Car rental of vehicles with open recalls

AQ26001 · Opened 2026-06-09

The 2021 Expedition is listed in this investigation record. An investigation concerns an agency inquiry; its opening is not a final defect determination, and closure alone is not a finding that every vehicle is safe or repaired.

Agency summary excerpt: “NHTSA is opening this Audit Query (AQ) to investigate NU Car Rentals (NU Car) for compliance with the requirements of the National Traffic and Motor Vehicle Safety Act.The Safety Act requires that a rental company shall not rent a vehicle …”

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 4 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2021 Ford Expedition, SUV · 4WD

NHTSA safety-data entry

SUV · 2WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2021 Ford Expedition, SUV · 2WD

Safety recall

Electrical System: Integrated Trailer Brake Control

NHTSA 22V193000 · Reported 2022-03-25 · Manufacturer campaign 22S17

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.”

Safety recall

Equipment: Other: Owners/Service/Other Manual

NHTSA 23V420000 · Reported 2023-06-09 · Manufacturer campaign 23C20

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."”

Safety recall

Equipment: Other: Labels

NHTSA 24V852000 · Reported 2024-11-08 · Manufacturer campaign 24C39

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."”

Safety recall

Electrical System: Integrated Trailer Brake Control

NHTSA 25V132000 · Reported 2025-02-28 · Manufacturer campaign 25S15

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.”

Safety recall

Service Brakes, Hydraulic: Foundation Components: Hoses, Lines/Piping, And Fittings

NHTSA 25V314000 · Reported 2025-05-09 · Manufacturer campaign 25S47

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.”

Safety recall

Fuel System, Gasoline: Delivery: Fuel Pump

NHTSA 25V455000 · Reported 2025-07-07 · Manufacturer campaign 25S75

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The low-pressure fuel pump may fail, which can result in an engine stall while driving.”

Safety recall

Visibility: Sun/Moon Roof Assembly

NHTSA 25V729000 · Reported 2025-10-24 · Manufacturer campaign 25SB7

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.”

Safety recall

Back Over Prevention: Software

NHTSA 25V315000 · Reported 2025-05-09 · Manufacturer campaign 25S49

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.”

Safety recall

Exterior Lighting: Tail Lights / Electrical System: Integrated Trailer Brake Control

NHTSA 26V104000 · Reported 2026-02-20 · Manufacturer campaign 26C10

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles …”

Safety recall

Visibility: Windshield Wiper/Washer: Linkages

NHTSA 26V204000 · Reported 2026-03-31 · Manufacturer campaign 26S24

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The windshield wiper arms may break, causing the wipers to fail.”

Safety recall

Seat Belts: Pretensioner

NHTSA 26V344000 · Reported 2026-05-27 · Manufacturer campaign 26S34

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.”

Safety recall

Structure: Interior Panels: Center Console

NHTSA 26V368000 · Reported 2026-06-09 · Manufacturer campaign 26S38

The campaign addresses injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The chrome plating on the center console may bubble and peel, resulting in sharp edges.”

Consumer allegations · 31 distinct reports

Visibility, cameras, and driver assistance

Received: 2022-08-23 through 2026-08-16

The text includes references to warnings or diagnostic codes (9), shifting or acceleration (7), software or module updates (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 30 distinct reports

Equipment and other reported systems

Received: 2022-08-18 through 2026-02-18

The text includes references to noise or vibration (6), warnings or diagnostic codes (3), shifting or acceleration (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 19 distinct reports

Electrical systems and software

Received: 2022-12-10 through 2026-07-13

The text includes references to warnings or diagnostic codes (6), noise or vibration (3), charging or battery concerns (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 15 distinct reports

Transmission and driveline

Received: 2022-08-18 through 2026-08-10

The text includes references to shifting or acceleration (11), warnings or diagnostic codes (4), software or module updates (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve gear selection, speed, load, vibration, and the repair procedure performed.

Consumer allegations · 14 distinct reports

Fuel and propulsion

Received: 2023-07-26 through 2026-09-17

The text includes references to charging or battery concerns (4), starting or stalling (3), warnings or diagnostic codes (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve fuel or charging conditions, power loss, warning messages, and confirmed diagnosis.

Consumer allegations · 13 distinct reports

Body and closures

Received: 2024-01-22 through 2026-09-17

The text includes references to inspection or repair procedures (3), noise or vibration (2), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the affected panel or closure, water entry, noise, photographs, and repair attempts.

Consumer allegations · 10 distinct reports

Engine and cooling

Received: 2023-05-19 through 2026-06-10

The text includes references to shifting or acceleration (4), starting or stalling (3), warnings or diagnostic codes (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve engine warnings, temperature, operating conditions, fluid levels, and repair findings.

Consumer allegations · 9 distinct reports

Brakes and stability control

Received: 2022-09-22 through 2026-07-13

The text includes references to leaks or water entry (3), warnings or diagnostic codes (2), inspection or repair procedures (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 5 distinct reports

Airbags, belts, and seating

Received: 2022-10-05 through 2026-09-17

The text includes references to warnings or diagnostic codes (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Consumer allegations · 3 distinct reports

Suspension, wheels, and tires

Received: 2024-09-27 through 2026-08-20

The text includes references to warnings or diagnostic codes (2), noise or vibration (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Consumer allegations · 3 distinct reports

Lighting and signals

Received: 2023-03-09 through 2025-07-26

The text includes references to warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the lamp or signal involved, conditions of use, warning indicators, and repair results.

Consumer allegations · 3 distinct reports

Steering

Received: 2025-08-20 through 2026-08-20

The text includes references to warnings or diagnostic codes (2), starting or stalling (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Service information · 69 distinct communications

Equipment and other reported systems

Communication dates: 2022-03-08 through 2026-08-22

The text includes references to warnings or diagnostic codes (17), software or module updates (17), noise or vibration (6). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 55 distinct communications

Electrical systems and software

Communication dates: 2022-03-14 through 2026-08-12

The text includes references to software or module updates (28), warnings or diagnostic codes (10), charging or battery concerns (9). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 32 distinct communications

Transmission and driveline

Communication dates: 2022-04-06 through 2026-07-02

The text includes references to software or module updates (15), shifting or acceleration (13), warnings or diagnostic codes (12). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 16 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2022-06-23 through 2026-01-31

The text includes references to software or module updates (9), warnings or diagnostic codes (5), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 7 distinct communications

Brakes and stability control

Communication dates: 2022-04-20 through 2026-06-11

The text includes references to warnings or diagnostic codes (3), noise or vibration (2), software or module updates (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

Service information · 6 distinct communications

Engine and cooling

Communication dates: 2022-06-02 through 2025-10-04

The text includes references to leaks or water entry (2), warnings or diagnostic codes (1), noise or vibration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check engine warnings, temperature, operating conditions, fluid levels, and repair findings against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Airbags, belts, and seating

Communication dates: 2022-02-17 through 2023-12-05

The text includes references to software or module updates (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 4 distinct communications

Fuel and propulsion

Communication dates: 2022-06-30 through 2026-07-23

The text includes references to warnings or diagnostic codes (2), charging or battery concerns (2), starting or stalling (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

Service information · 3 distinct communications

Body and closures

Communication dates: 2023-02-07 through 2023-04-04

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Steering

Communication dates: 2023-06-14 through 2023-09-13

The text includes references to noise or vibration (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check steering effort, vehicle speed, direction of travel, and diagnostic findings against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Suspension, wheels, and tires

Communication dates: 2022-04-28

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check speed, road conditions, tire condition, alignment measurements, and replaced parts against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Lighting and signals

Communication dates: 2023-05-09

The text includes references to warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the lamp or signal involved, conditions of use, warning indicators, and repair results against the document’s VIN, trim, and equipment limits.

Agency record · Closed

Low-pressure fuel pump failure

PE24019 · Opened 2024-07-29 · Closed 2025-09-19

The 2022 Expedition is listed in this investigation record. An investigation concerns an agency inquiry; its opening is not a final defect determination, and closure alone is not a finding that every vehicle is safe or repaired.

Agency summary excerpt: “On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a …”

NHTSA safety-data entry

SUV · 2WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2022 Ford Expedition, SUV · 2WD

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 4 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2022 Ford Expedition, SUV · 4WD

Safety recall

Equipment: Other: Owners/Service/Other Manual

NHTSA 23V420000 · Reported 2023-06-09 · Manufacturer campaign 23C20

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."”

Safety recall

Power Train: Axle Assembly

NHTSA 23V128000 · Reported 2023-02-24 · Manufacturer campaign 23S07

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The front axle pinion may not have been heat-treated, which can cause it to fracture.”

Safety recall

Equipment: Other: Labels

NHTSA 24V852000 · Reported 2024-11-08 · Manufacturer campaign 24C39

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."”

Safety recall

Service Brakes, Hydraulic: Foundation Components: Hoses, Lines/Piping, And Fittings

NHTSA 25V314000 · Reported 2025-05-09 · Manufacturer campaign 25S47

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.”

Safety recall

Back Over Prevention: Software

NHTSA 25V315000 · Reported 2025-05-09 · Manufacturer campaign 25S49

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.”

Safety recall

Exterior Lighting: Tail Lights / Electrical System: Integrated Trailer Brake Control

NHTSA 26V104000 · Reported 2026-02-20 · Manufacturer campaign 26C10

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles …”

Safety recall

Visibility: Windshield Wiper/Washer: Linkages

NHTSA 26V204000 · Reported 2026-03-31 · Manufacturer campaign 26S24

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The windshield wiper arms may break, causing the wipers to fail.”

Safety recall

Structure: Interior Panels: Center Console

NHTSA 26V368000 · Reported 2026-06-09 · Manufacturer campaign 26S38

The campaign addresses injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The chrome plating on the center console may bubble and peel, resulting in sharp edges.”

Consumer allegations · 19 distinct reports

Equipment and other reported systems

Received: 2023-05-10 through 2026-06-26

The text includes references to shifting or acceleration (6), warnings or diagnostic codes (5), inspection or repair procedures (4). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 16 distinct reports

Electrical systems and software

Received: 2023-05-10 through 2026-07-10

The text includes references to warnings or diagnostic codes (3), shifting or acceleration (3), noise or vibration (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 10 distinct reports

Visibility, cameras, and driver assistance

Received: 2023-11-07 through 2025-12-28

The text includes references to warnings or diagnostic codes (4), software or module updates (3), inspection or repair procedures (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 11 distinct reports

Transmission and driveline

Received: 2023-07-25 through 2026-07-17

The text includes references to shifting or acceleration (5), warnings or diagnostic codes (3), leaks or water entry (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve gear selection, speed, load, vibration, and the repair procedure performed.

Consumer allegations · 7 distinct reports

Engine and cooling

Received: 2023-12-20 through 2026-05-26

The text includes references to leaks or water entry (2), shifting or acceleration (2), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve engine warnings, temperature, operating conditions, fluid levels, and repair findings.

Consumer allegations · 5 distinct reports

Body and closures

Received: 2023-08-23 through 2026-07-07

The text includes references to warnings or diagnostic codes (2), software or module updates (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the affected panel or closure, water entry, noise, photographs, and repair attempts.

Consumer allegations · 5 distinct reports

Suspension, wheels, and tires

Received: 2023-09-04 through 2024-11-15

The text includes references to noise or vibration (2), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Consumer allegations · 5 distinct reports

Brakes and stability control

Received: 2025-07-13 through 2026-07-03

The text includes references to warnings or diagnostic codes (4), inspection or repair procedures (2), starting or stalling (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 4 distinct reports

Fuel and propulsion

Received: 2023-04-26 through 2025-08-24

The text includes references to noise or vibration (1), shifting or acceleration (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve fuel or charging conditions, power loss, warning messages, and confirmed diagnosis.

Consumer allegations · 4 distinct reports

Airbags, belts, and seating

Received: 2024-03-22 through 2025-11-17

The text includes references to warnings or diagnostic codes (2), noise or vibration (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Consumer allegations · 2 distinct reports

Steering

Received: 2023-10-03 through 2026-07-22

The text includes references to noise or vibration (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Service information · 58 distinct communications

Equipment and other reported systems

Communication dates: 2022-12-20 through 2026-07-09

The text includes references to software or module updates (14), warnings or diagnostic codes (13), noise or vibration (6). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 44 distinct communications

Electrical systems and software

Communication dates: 2023-01-19 through 2026-08-12

The text includes references to software or module updates (24), warnings or diagnostic codes (9), noise or vibration (5). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 23 distinct communications

Transmission and driveline

Communication dates: 2023-03-08 through 2026-07-02

The text includes references to software or module updates (9), warnings or diagnostic codes (6), shifting or acceleration (6). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 10 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2023-08-18 through 2025-10-24

The text includes references to software or module updates (6), warnings or diagnostic codes (4), leaks or water entry (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 10 distinct communications

Engine and cooling

Communication dates: 2023-11-30 through 2025-11-20

The text includes references to noise or vibration (3), inspection or repair procedures (2), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check engine warnings, temperature, operating conditions, fluid levels, and repair findings against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Airbags, belts, and seating

Communication dates: 2023-01-23 through 2026-08-22

The text includes references to software or module updates (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Body and closures

Communication dates: 2023-02-07 through 2023-10-02

The text includes references to software or module updates (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 3 distinct communications

Steering

Communication dates: 2023-06-14 through 2023-09-13

The text includes references to noise or vibration (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check steering effort, vehicle speed, direction of travel, and diagnostic findings against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Brakes and stability control

Communication dates: 2022-12-16 through 2023-05-05

The text includes references to warnings or diagnostic codes (1), noise or vibration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Fuel and propulsion

Communication dates: 2026-07-23

The text includes references to warnings or diagnostic codes (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

NHTSA safety-data entry

SUV · RWD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2023 Ford Expedition, SUV · RWD

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 4 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2023 Ford Expedition, SUV · 4WD

Safety recall

Engine And Engine Cooling: Engine: Oil/Lubrication

NHTSA 24V851000 · Reported 2024-12-20 · Manufacturer campaign 24S70

The campaign addresses crash risk, fire risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The engines may have a misaligned engine cup plug, which can result in a rapid oil leak.”

Safety recall

Equipment: Other: Labels

NHTSA 24V852000 · Reported 2024-11-08 · Manufacturer campaign 24C39

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."”

Safety recall

Service Brakes, Hydraulic: Foundation Components: Hoses, Lines/Piping, And Fittings

NHTSA 25V314000 · Reported 2025-05-09 · Manufacturer campaign 25S47

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.”

Safety recall

Engine And Engine Cooling: Engine: Oil/Lubrication

NHTSA 25V198000 · Reported 2025-03-28 · Manufacturer campaign 25S30

The campaign addresses crash risk, fire risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.”

Safety recall

Back Over Prevention: Software

NHTSA 25V315000 · Reported 2025-05-09 · Manufacturer campaign 25S49

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.”

Safety recall

Exterior Lighting: Tail Lights / Electrical System: Integrated Trailer Brake Control

NHTSA 26V104000 · Reported 2026-02-20 · Manufacturer campaign 26C10

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles …”

Safety recall

Structure: Interior Panels: Center Console

NHTSA 26V368000 · Reported 2026-06-09 · Manufacturer campaign 26S38

The campaign addresses injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The chrome plating on the center console may bubble and peel, resulting in sharp edges.”

Consumer allegations · 20 distinct reports

Visibility, cameras, and driver assistance

Received: 2025-02-11 through 2026-07-17

The text includes references to warnings or diagnostic codes (9), software or module updates (4), shifting or acceleration (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 24 distinct reports

Equipment and other reported systems

Received: 2024-07-13 through 2026-09-18

The text includes references to warnings or diagnostic codes (5), noise or vibration (5), shifting or acceleration (5). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 15 distinct reports

Electrical systems and software

Received: 2024-08-03 through 2026-09-21

The text includes references to warnings or diagnostic codes (4), software or module updates (4), charging or battery concerns (3). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 9 distinct reports

Brakes and stability control

Received: 2024-05-10 through 2025-12-02

The text includes references to warnings or diagnostic codes (4), shifting or acceleration (2), inspection or repair procedures (2). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 7 distinct reports

Suspension, wheels, and tires

Received: 2024-12-13 through 2026-09-18

The text includes references to noise or vibration (4), inspection or repair procedures (3), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Consumer allegations · 6 distinct reports

Airbags, belts, and seating

Received: 2025-06-19 through 2026-07-17

The text includes references to warnings or diagnostic codes (1), software or module updates (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Consumer allegations · 4 distinct reports

Steering

Received: 2024-12-13 through 2026-09-18

The text includes references to noise or vibration (2), charging or battery concerns (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Consumer allegations · 5 distinct reports

Transmission and driveline

Received: 2025-01-25 through 2026-04-29

The text includes references to shifting or acceleration (2), warnings or diagnostic codes (1), leaks or water entry (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve gear selection, speed, load, vibration, and the repair procedure performed.

Consumer allegations · 5 distinct reports

Engine and cooling

Received: 2025-05-25 through 2026-06-29

The text includes references to inspection or repair procedures (4), warnings or diagnostic codes (3), leaks or water entry (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve engine warnings, temperature, operating conditions, fluid levels, and repair findings.

Consumer allegations · 4 distinct reports

Body and closures

Received: 2025-02-03 through 2026-07-24

The text includes references to charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the affected panel or closure, water entry, noise, photographs, and repair attempts.

Consumer allegations · 2 distinct reports

Fuel and propulsion

Received: 2024-07-27 through 2025-08-26

The text includes references to warnings or diagnostic codes (2), leaks or water entry (1), shifting or acceleration (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve fuel or charging conditions, power loss, warning messages, and confirmed diagnosis.

Service information · 50 distinct communications

Equipment and other reported systems

Communication dates: 2023-12-08 through 2026-07-09

The text includes references to software or module updates (15), warnings or diagnostic codes (11), shifting or acceleration (5). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 17 distinct communications

Transmission and driveline

Communication dates: 2023-11-14 through 2026-07-02

The text includes references to inspection or repair procedures (4), noise or vibration (3), software or module updates (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 15 distinct communications

Electrical systems and software

Communication dates: 2024-03-01 through 2026-08-12

The text includes references to software or module updates (9), warnings or diagnostic codes (4), starting or stalling (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 7 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2023-12-05 through 2026-01-31

The text includes references to warnings or diagnostic codes (3), software or module updates (3), leaks or water entry (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 7 distinct communications

Engine and cooling

Communication dates: 2024-02-26 through 2025-11-20

The text includes references to noise or vibration (3), inspection or repair procedures (2), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check engine warnings, temperature, operating conditions, fluid levels, and repair findings against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Fuel and propulsion

Communication dates: 2025-08-14 through 2026-07-23

The text includes references to leaks or water entry (2), charging or battery concerns (2), starting or stalling (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Airbags, belts, and seating

Communication dates: 2023-12-05 through 2026-08-22

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Body and closures

Communication dates: 2024-02-16

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Brakes and stability control

Communication dates: 2026-06-11

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 4 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2024 Ford Expedition, SUV · 4WD

NHTSA safety-data entry

SUV · RWD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

NHTSA safety-rating dataset — 2024 Ford Expedition, SUV · RWD

Safety recall

Service Brakes, Hydraulic: Power Assist: Electric: Control Module

NHTSA 25V823000 · Reported 2025-12-01 · Manufacturer campaign 25SD4

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.”

Safety recall

Service Brakes, Hydraulic: Power Assist: Electric: Control Module: Software

NHTSA 25V488000 · Reported 2025-07-25 · Manufacturer campaign 25S77

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.”

Safety recall

Engine And Engine Cooling: Engine: Oil/Lubrication

NHTSA 25V198000 · Reported 2025-03-28 · Manufacturer campaign 25S30

The campaign addresses crash risk, fire risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.”

Safety recall

Air Bags: Frontal

NHTSA 25V439000 · Reported 2025-06-27 · Manufacturer campaign 25S51

The campaign addresses crash risk, injury risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “The passenger side air bag may have been manufactured incorrectly, which can cause the air bag to deploy with excessive force during a crash.”

Safety recall

Exterior Lighting: Tail Lights / Electrical System: Integrated Trailer Brake Control

NHTSA 26V104000 · Reported 2026-02-20 · Manufacturer campaign 26C10

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles …”

Consumer allegations · 11 distinct reports

Visibility, cameras, and driver assistance

Received: 2025-10-09 through 2026-09-17

The text includes references to warnings or diagnostic codes (3), inspection or repair procedures (2), shifting or acceleration (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 7 distinct reports

Airbags, belts, and seating

Received: 2025-07-07 through 2026-06-11

The text includes references to warnings or diagnostic codes (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Consumer allegations · 6 distinct reports

Brakes and stability control

Received: 2025-07-07 through 2026-08-12

The text includes references to warnings or diagnostic codes (3), inspection or repair procedures (2), software or module updates (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 6 distinct reports

Steering

Received: 2025-12-08 through 2026-09-20

The text includes references to warnings or diagnostic codes (2), noise or vibration (2), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Consumer allegations · 6 distinct reports

Equipment and other reported systems

Received: 2026-02-13 through 2026-08-23

The text includes references to warnings or diagnostic codes (1), software or module updates (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 5 distinct reports

Electrical systems and software

Received: 2025-07-07 through 2026-08-12

The text includes references to warnings or diagnostic codes (2), software or module updates (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 5 distinct reports

Transmission and driveline

Received: 2025-08-08 through 2026-09-20

The text includes references to noise or vibration (2), warnings or diagnostic codes (1), software or module updates (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve gear selection, speed, load, vibration, and the repair procedure performed.

Consumer allegations · 5 distinct reports

Suspension, wheels, and tires

Received: 2025-12-29 through 2026-09-20

The text includes references to noise or vibration (2), warnings or diagnostic codes (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Consumer allegations · 2 distinct reports

Engine and cooling

Received: 2025-08-08 through 2026-09-04

The text includes references to inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve engine warnings, temperature, operating conditions, fluid levels, and repair findings.

Consumer allegations · 2 distinct reports

Body and closures

Received: 2025-10-30 through 2026-02-02

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the affected panel or closure, water entry, noise, photographs, and repair attempts.

Consumer allegations · 1 distinct reports

Fuel and propulsion

Received: 2026-06-12

The text includes references to charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve fuel or charging conditions, power loss, warning messages, and confirmed diagnosis.

Service information · 35 distinct communications

Equipment and other reported systems

Communication dates: 2025-04-01 through 2026-08-26

The text includes references to software or module updates (9), warnings or diagnostic codes (5), charging or battery concerns (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 35 distinct communications

Electrical systems and software

Communication dates: 2025-06-04 through 2026-08-27

The text includes references to software or module updates (16), charging or battery concerns (6), starting or stalling (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 15 distinct communications

Body and closures

Communication dates: 2025-05-30 through 2026-06-09

The text includes references to software or module updates (5), warnings or diagnostic codes (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 14 distinct communications

Transmission and driveline

Communication dates: 2025-06-05 through 2026-05-30

The text includes references to noise or vibration (3), leaks or water entry (3), inspection or repair procedures (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 11 distinct communications

Airbags, belts, and seating

Communication dates: 2025-05-23 through 2026-04-22

The text includes references to software or module updates (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 9 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2025-06-03 through 2026-08-06

The text includes references to software or module updates (4), warnings or diagnostic codes (2), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Engine and cooling

Communication dates: 2025-05-13 through 2025-11-20

The text includes references to noise or vibration (3), warnings or diagnostic codes (1), leaks or water entry (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check engine warnings, temperature, operating conditions, fluid levels, and repair findings against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Fuel and propulsion

Communication dates: 2025-08-14 through 2026-07-23

The text includes references to charging or battery concerns (2), starting or stalling (1), warnings or diagnostic codes (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

Service information · 4 distinct communications

Brakes and stability control

Communication dates: 2025-06-05 through 2026-04-09

The text includes references to warnings or diagnostic codes (2), software or module updates (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

Service information · 4 distinct communications

Suspension, wheels, and tires

Communication dates: 2025-06-20 through 2025-11-03

The text includes references to noise or vibration (4). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check speed, road conditions, tire condition, alignment measurements, and replaced parts against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Steering

Communication dates: 2025-12-16 through 2026-04-22

The text includes references to warnings or diagnostic codes (1), noise or vibration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check steering effort, vehicle speed, direction of travel, and diagnostic findings against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Lighting and signals

Communication dates: 2026-03-02

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the lamp or signal involved, conditions of use, warning indicators, and repair results against the document’s VIN, trim, and equipment limits.

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

Source cautions: During the side barrier test, this vehicle rolled onto its side (one-quarter turn) after impact; the driver side curtain air bag deployed behind the B-pillar trim. During the side pole test, the driver side curtain air bag was caught at the B-pillar.

NHTSA safety-rating dataset — 2025 Ford Expedition, SUV · 4WD

NHTSA safety-data entry

SUV · RWD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

Source cautions: During the side barrier test, this vehicle rolled onto its side (one-quarter turn) after impact; the driver side curtain air bag deployed behind the B-pillar trim. During the side pole test, the driver side curtain air bag was caught at the B-pillar.

NHTSA safety-rating dataset — 2025 Ford Expedition, SUV · RWD

Safety recall

Exterior Lighting: Tail Lights / Electrical System: Integrated Trailer Brake Control

NHTSA 26V104000 · Reported 2026-02-20 · Manufacturer campaign 26C10

The campaign addresses crash risk involving the listed component. Its applicability is limited to the affected vehicles and equipment described by Ford Motor Company.

Reported condition: “When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles …”

Consumer allegations · 5 distinct reports

Suspension, wheels, and tires

Received: 2026-05-07 through 2026-08-07

The text includes references to warnings or diagnostic codes (1), noise or vibration (1), software or module updates (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve speed, road conditions, tire condition, alignment measurements, and replaced parts.

Consumer allegations · 4 distinct reports

Steering

Received: 2026-03-21 through 2026-08-07

The text includes references to warnings or diagnostic codes (1), noise or vibration (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve steering effort, vehicle speed, direction of travel, and diagnostic findings.

Consumer allegations · 4 distinct reports

Equipment and other reported systems

Received: 2026-03-21 through 2026-07-23

The text includes references to noise or vibration (2), warnings or diagnostic codes (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the exact customer concern, affected equipment, configuration, and final repair findings.

Consumer allegations · 2 distinct reports

Visibility, cameras, and driver assistance

Received: 2026-04-01 through 2026-09-10

The text includes references to warnings or diagnostic codes (2), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve weather, visibility, displayed warnings, software versions, and sensor calibration.

Consumer allegations · 1 distinct reports

Brakes and stability control

Received: 2026-06-14

The text includes references to software or module updates (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve pedal response, warning lights, road conditions, and the technician’s findings.

Consumer allegations · 1 distinct reports

Electrical systems and software

Received: 2026-06-14

The text includes references to software or module updates (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve warning messages, battery tests, software versions, module replacements, and recurrence.

Consumer allegations · 1 distinct reports

Airbags, belts, and seating

Received: 2026-08-07

These submissions are grouped by their NHTSA component tags. They are allegations, not agency findings, and a report can carry more than one tag. For a case-specific comparison, preserve the seating position, restraint equipment, warning messages, and installed parts.

Service information · 14 distinct communications

Equipment and other reported systems

Communication dates: 2026-01-17 through 2026-08-26

The text includes references to charging or battery concerns (2), starting or stalling (1), shifting or acceleration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the exact customer concern, affected equipment, configuration, and final repair findings against the document’s VIN, trim, and equipment limits.

Service information · 11 distinct communications

Electrical systems and software

Communication dates: 2026-02-09 through 2026-08-27

The text includes references to software or module updates (5), warnings or diagnostic codes (2), charging or battery concerns (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check warning messages, battery tests, software versions, module replacements, and recurrence against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Body and closures

Communication dates: 2026-02-16 through 2026-07-14

The text includes references to software or module updates (2). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the affected panel or closure, water entry, noise, photographs, and repair attempts against the document’s VIN, trim, and equipment limits.

Service information · 5 distinct communications

Visibility, cameras, and driver assistance

Communication dates: 2026-04-02 through 2026-06-09

The text includes references to software or module updates (3). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check weather, visibility, displayed warnings, software versions, and sensor calibration against the document’s VIN, trim, and equipment limits.

Service information · 4 distinct communications

Transmission and driveline

Communication dates: 2026-02-17 through 2026-05-30

The text includes references to leaks or water entry (2), shifting or acceleration (1), inspection or repair procedures (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check gear selection, speed, load, vibration, and the repair procedure performed against the document’s VIN, trim, and equipment limits.

Service information · 3 distinct communications

Steering

Communication dates: 2025-12-16 through 2026-06-11

The text includes references to warnings or diagnostic codes (1), noise or vibration (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check steering effort, vehicle speed, direction of travel, and diagnostic findings against the document’s VIN, trim, and equipment limits.

Service information · 3 distinct communications

Airbags, belts, and seating

Communication dates: 2026-02-28 through 2026-04-20

The text includes references to software or module updates (2), starting or stalling (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the seating position, restraint equipment, warning messages, and installed parts against the document’s VIN, trim, and equipment limits.

Service information · 2 distinct communications

Fuel and propulsion

Communication dates: 2026-04-01 through 2026-07-23

The text includes references to warnings or diagnostic codes (1), charging or battery concerns (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check fuel or charging conditions, power loss, warning messages, and confirmed diagnosis against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Brakes and stability control

Communication dates: 2026-04-09

The text includes references to warnings or diagnostic codes (1), software or module updates (1). These are text themes, not verified causes or separate failure counts.

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check pedal response, warning lights, road conditions, and the technician’s findings against the document’s VIN, trim, and equipment limits.

Service information · 1 distinct communications

Lighting and signals

Communication dates: 2026-04-10

This group collects manufacturer instructions under the listed system. A bulletin may concern diagnosis, routine service, parts, software, or administration; its existence does not establish that every vehicle has a defect. Check the lamp or signal involved, conditions of use, warning indicators, and repair results against the document’s VIN, trim, and equipment limits.

NHTSA safety-data entry

SUV · RWD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

Source cautions: During the side barrier test, this vehicle rolled onto its side (one-quarter turn) after impact; the driver side curtain air bag deployed behind the B-pillar trim. During the side pole test, the driver side curtain air bag was caught at the B-pillar.

NHTSA safety-rating dataset — 2026 Ford Expedition, SUV · RWD

NHTSA safety-data entry

SUV · 4WD

Overall: 5 of 5 stars · Frontal: 5 of 5 stars · Side: 5 of 5 stars · Rollover: 3 of 5 stars

These results belong to the stated model year and configuration. Do not transfer them to a different body style, drivetrain, or trim. A rating does not resolve whether a particular vehicle has an open recall or recurring repair condition.

Source cautions: During the side barrier test, this vehicle rolled onto its side (one-quarter turn) after impact; the driver side curtain air bag deployed behind the B-pillar trim. During the side pole test, the driver side curtain air bag was caught at the B-pillar.

NHTSA safety-rating dataset — 2026 Ford Expedition, SUV · 4WD